JLG M600 Service Manual - Manual (Page 15)

SECTION 1 - SPECIFICATIONS
3121813 – JLG Lift – 1-1
SECTION 1. SPECIFICATIONS
1.1 CAPACITIES
1.2 OPERATING SPECIFICATIONS
1.3 GENERATOR
1.4 BATTERY CHARGER
1.5 DRIVE/STEER SYSTEM
1.6 TIRES
Table 1-1. Capacities
Generator Fuel Tank (M Models Only) 13 gallons (49.2 liters)
Hydraulic Tank
Prior to S/N 51941
S/N 51941 to Present
15 gallons (57 liters)
15.9 gal.(60.2 L)
12.4 gal. (46.9 L) to full mark
Drive Hub 0.4 gal. (1.5 liters)
Table 1-2. Operating Specifications
Maximum Work Load (Capacity)
Unrestricted:
500 lb (230 kg)
Maximum Travel Grade (Gradeability)
with Boom retracted and approximately
horizontal. Tower Boom fully lowered. 30%
Maximum Travel Grade (Side Slope) with
Boom retracted and approximately hori-
zontal. Tower Boom fully lowered.
5°
Tilt Alarm Setting (See Section 3)
ANSI, CSA
CE E/M600 & E/M600J
CE E/M 600JP
5°
4°
3°
Maximum Vertical Platform Height: 60 ft. (18.29 m)
Maximum Horizontal Platform Reach
E600
E600J
43 ft. (13.11 m)
42 ft. 9 in. (13.11 m)
Machine Width
2WD
4WD
7 ft. 11 7/16 in. (2.42 m)
7 ft. 11 3/8 in. (2.42 m)
Machine Length
E/M600
E/M600J
E/M600JP
30 ft. 11 5/16 in. (9.43 m)
30 ft. 8 15/16 in. (9.37 m)
33 ft. 3 3/4 in. (10.15 m)
Turning Radius (outside) 15 ft. 3 in. (4.65 m)
Turning Radius (inside) 4 ft. (1.23 m)
Maximum Tire Load: 7700 lbs. (3500 kg)
Maximum Ground Bearing Pressure
E600J/M600J
E600JP/M600JP
52 psi (3.7 kg/cm 2)
51 psi (3.6 kg/cm 2)
Maximum Drive Speed: 3.0 mph (1.3 m/s)
Electrical System Voltage 48 volts
Maximum Hydraulic System Pressure 3200 psi (221 Bar)
Maximum Wind Speed 28 mph (12.5 m/s)
Maximum Manual Force 400N
Gross Machine Weight (Platform Empty)
E600J/M600J
E600JP/M600JP
16,300 lb. (7,393 kg)
16,800 lb. (7,620 kg)
Table 1-3. Generator
Alternator Output 58 volts @ 45 Amps
RPM’s under max. load 3100
Start Battery 12 volts
Engine Oil 10W30 (Refer to Engine Manual)
Dynamo 12 volt, 15 amp DC
Dynamo Output Fuse 20 amps DC
Control Fuse 15 amps DC
Table 1-4. Battery Charger
AC Input 120V - 240V Auto Seeking
AC Draw 17 amps at start of charging
DC Output 48 volts, 23 amps
Table 1-5. Drive System
Drive Motor 48 VDC, 12.5 H.P. @ 3200 rpm. con-
tinuous, rotation - reversible
Drive Brake spring-applied, hydraulically released
Table 1-6. Tires
Size Type Pressure
36/14 LL-22.5 pneumatic 55 psi (4.0 Bar)
36/14 LL-22.5 foam filled N/A
Table 1-2. Operating Specifications