Continental Fireplaces CDVS600 - Manual (Page 2)

2
W415-0791 / C / 04.18.12
NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.
TABLE OF CONTENTS
1.0
INSTALLATION OVERVIEW 3
2.0 INTRODUCTION 4
2.1 DIMENSIONS 5
2.2 GENERAL INSTRUCTIONS 5
2.3 GENERAL INFORMATION 6
2.4 RATING PLATE INFORMATION 7
2.5 SHIPPING BRACKET 8
3.0 VENTING - MODEL CDVS600 9
3.1 VENTING LENGTHS AND COMPONENTS 10
3.2 TYPICAL VENT INSTALLATIONS 11
3.3 SPECIAL VENT INSTALLATIONS 13
3.3.1 PERISCOPE TERMINATION 13
3.3.2 CORNER TERMINATION 13
3.4 VENT TERMINAL CLEARANCES 14
3.5 VENTING APPLICATION FLOW CHART 15
3.6 DEFINITIONS 16
3.7 ELBOW VENT LENGTH VALUES 16
3.8 TOP EXIT HORIZONTAL TERMINATION 17
3.9 TOP EXIT HORIZONTAL TERMINATION 18
3.10 REAR EXIT HORIZONTAL TERMINATION 19
3.11 TOP OR REAR EXIT VERTICAL TERMINATION 21
4.0 INSTALLATION PREPARATION - MODEL CDVS600 23
4.1 ORIFICE REPLACEMENT 23
4.2 CHANGING A TOP VENT TO A REAR VENT 24
5.0 INSTALLATION 25
5.1 MINIMUM CLEARANCE TO COMBUSTIBLES 25
5.2 WALL AND CEILING PROTECTION 26
5.2.1 HORIZONTAL INSTALLATION 26
5.2.2 VERTICAL INSTALLATION 27
5.2.3 HORIZONTAL AIR TERMINAL INSTALLATION - MODEL CDVS600 28
5.2.4 VERTICAL AIR TERMINAL INSTALLATION - MODEL CDVS600 29
5.3 APPLIANCE VENT CONNECTION - MODEL CDVS600 30
5.4 VERTICAL THROUGH EXISTING CHIMNEY 31
5.5 MOBILE HOME INSTALLATION - MODEL CDVS600 32
5.6 GAS INSTALLATION 32
5.7 OPTIONAL WALL SWITCH / THERMOSTAT 32
5.8 NATURAL VENT SPECIFICS - MODEL CS600 33
5.8.1 CHIMNEY INSTALLATION 33
5.8.2 INSTALLING NATURAL VENT 34
5.8.3 NATURAL VENT 34
5.8.4 COMBUSTION AIR 34
5.8.5 ADDING VENT SECTIONS 35
5.8.6 INSTALLING FLASHING AND STORM COLLAR 36
6.0 FINISHING 37
6.1 FRONT CAST REMOVAL 37
6.2 GLASS DOOR INSTALLATION AND REMOVAL 37
6.3 GLASS / DOOR REPLACEMENT 38
6.4 LOG PLACEMENT 38
6.5 GLOWING EMBERS 39
6.6 LOGO PLACEMENT 39
6.7 SWITCH AND BRACKET INSTALLATION 40
7.0 OPTIONAL BLOWER INSTALLATION 41
8.0 WIRING DIAGRAM 42
9.0 OPERATION 43
9.1 OPERATING INSTRUCTIONS 43
9.2 OPERATING INSTRUCTIONS - FOR YOUR SAFETY READ BEFORE OPERATING 44
9.3 LIGHTING INSTRUCTIONS 44
9.4 ANTI CONDENSATION SWITCH 44
10.0 ADJUSTMENT 45
10.1 PILOT BURNER ADJUSTMENT 45
10.2 VENTURI ADJUSTMENT 45
10.3 FLAME CHARACTERISTICS 45
10.4 RESTRICTING VERTICAL VENTS - MODEL CDVS600 46
11.0 MAINTENANCE 46
11.1 CARE OF GLASS 46
12.0 REPLACEMENTS 47
13.0 TROUBLESHOOTING 51
14.0 WARRANTY 54
15.0 SERVICE HISTORY 55