MBM Corporation STITCHFOLD Trimmer - Manual (Page 4)

4
Trimmer
SAFETY
A. Top Cover: Blocks access to mechanism that
drives the trimming knife and conveyor belts.
An electrical interlock keeps the machine
turned off unless this guard is closed. Do not
stick your fingers under the top guard!
B. Front Upper Cover: Blocks access to the trim-
ming knives and the mechanism that drives the
upper trimming knife.
C. Infeed Table Bottom Cover: Blocks access to
infeed conveyor belts.
D. Front Lower Cover: Blocks access to danger-
ous electric voltage and mechanisms that can
pinch or cut. Be sure to disconnect electrical
power before removing this cover.
E. Right Side Cover: Blocks access to low volt-
age connections and mechanisms that can pinch
or cut. Do not stick your fingers beyond this
cover!
F. Rear Upper Cover: Blocks access to danger-
ous electric voltage and control circuit con-
nections. Be sure to disconnect electrical
power before removing this cover.
G. Rear Lower Cover: Blocks access to low volt-
age connections and mechanisms that can pinch
or cut. Do not stick your fingers beyond this
cover!
H. Left Side Cover: Blocks access to low volt-
age connections and mechanisms that can pinch
or cut. Do not stick your fingers beyond this
cover!
SAFETY GUARDS (figs 1 & 2)
1. Make sure electrical power is turned off be-
fore performing any adjustment or mainte-
nance.
2. Keep hands, hair, tools, and clothing clear of
trimming area.
3. Become familiar with the moving components
of your machine. Keep fingers away from
areas that could pinch or cut.
4. BE EXTREMELY CAREFUL when changing
the cutter knife. Severe lacerations or dis-
memberment could result from careless han-
dling procedures.
5. NEVER REACH UNDER THE KNIFE Severe
lacerations or dismemberment could result.
6. NEVER OPERATE THE TRIMMER WITHOUT
THE B2000 BOOKLETMAKER AND SAFETY
INTERLOCK SYSTEM.
6. A well maintained machine is a safer machine.
Clean and lubricate the machine at regular in-
tervals. Check machine daily for broken or
worn parts. Replace as necessary. DO NOT
attempt to operate the machine if a part is bro-
ken.
7. See "SAFETY GUARDS" below! If you are
unsure how to safely operate your trimmer, contact
your Service Representative.
SAFETY PRECAUTIONS AND PROCEDURES
DANGER
KEEP HANDS CLEAR OF TRIMMING AREA AND ANY MOVING PARTS!
NEVER OPERATE MACHINE WITHOUT ALL GUARDS IN PLACE!