Two Brothers Racing Honda TRX700XX - Manual

Two Brothers Racing
Juice Box™ - Fuel Controller
2008 Honda TRX700XX Installation & Operation Manual
Part # 008-201
Parts Incuded
Installation Instructions
Qty. Description Part Number
1 Juice Box™ Fuel Control Kit 008-201 (9310121)
3 Zip Ties
1 Adhesive Velcro Square
V.A.L.E.
V a r i a b l e a x i s l o c k i n g e x h a u s t
TM
Route JUICE BOX™ harness along the air-box so that
the JUICE BOX™ will fit into the spot in the lower Left
hand corner, next to the air-box. Make sure that the
seat doesn’t in any way contact the JUICE BOX™ unit or
wiring harness and secure with zip ties. (Fig 4)
NOTE: Re-check your wire routing and JUICE BOX™
location and make certain that in no way the wires can
come into contact with any moving parts or high heat
source and that the JUICE BOX™ is mounted in a way as
to not cause a handling problem with the machine.
Start the ATV and double check to make sure the JUICE
BOX™ lights up.
Reassembly is the opposite of disassembly.
5.
6.
7.
8.
IMPORTANT - PLEASE READ CAREFULLY
Warranty
two brothers racing warrants that this product carries a warranty for 2 years from date of purchase against original
defects in materials and workmanship. should this product fail to perform for either of the above reasons, two brothers
racing will repair or replace it with an equivalent product at no charge, except for postage, to the original retail purchaser.
to obtain the benefits of this warranty, the retail purchaser must return the product and proof of purchase to the place of
original purchase.
We recommend that this performance part be installed by a qualified ATV technician. If
you have any doubts as to your ability to install this performance part, please consult
with your local ATV dealer. Read all instructions first before starting installation. Make
sure the vehicle and exhaust system are completely cool before starting the installation.
Also, make sure the vehicle is secure during installation. Be sure to save all stock
components for possible use later.
The Juice Box™ is legal ONLY for closed course race vehicles. The Juice Box™ is not
applicable, nor inteded for use on EMISSIONS CONTROLLED street, highway or off-road
vehicles. The Juice Box™ is not applicable, nor inteded for use on aircraft.
Thank you for purchasing a genuine Two Brothers Racing
JUICE BOX™. This product represents a radical step
forward in tuning fuel-injected motorcycles and ATVs for
optimal performance using “load-based” technology.
We at Two Brothers Racing hope that you will find this
development as exciting and useful as we do. And
remember: Proper Fuel = Maximum Power!
Make sure the vehicle is completely cool before starting
the installation. Also, make sure the vehicle is secure and
will not roll around.
Remove seat.
Pull back the rubber matting, then the plastic cover (Fig 1).
Locate (Fig 2) and disconnect stock injector connector,
connect JUICE BOX™ connector to ATV’s injector then
connect stock injector connector to JUICE BOX™’s black
connector. (Fig 3)
1.
2.
3.
4.
Fig 1
Continued on page 2
Fig 4
Fig 2
Fig 3