DR Power Dual Action 10-Ton Electric (Aug 2011 - Present) - Manual (Page 6)

6 DR ® DUAL-ACTION ELECTRIC LOG SPLITTER
A Note to All Users
No list of warnings and cautions can be all-inclusive. If situations occur that are not covered by this manual, the operator must
apply common sense and operate this DR DUAL-ACTION ELECTRIC LOG SPLITTER in a safe manner. Contact us at
www.DRpower.com or call 1-800-DR-OWNER (376-9637) for assistance.

Allow only one person to operate the Log Splitter at any time.

If the machine should start making an unusual noise or vibration, turn the machine off and unplug the electrical cord and
allow the machine to cool, then inspect for damage. Vibration is generally a warning of trouble. Check for damaged parts and
clean, repair and/or replace as necessary.

Never tamper with safety devices. Check their proper operation regularly.

Never allow people who are unfamiliar with these instructions to use the Log Splitter. Allow only responsible individuals who
are familiar with these rules of safe operation to use your machine.
 Never overload or attempt to split logs beyond the manufacturer’s recommendation. Personal injury or damage to the
machine could result.

While using the Log Splitter, don't hurry or take things for granted. When in doubt about the equipment or your surroundings
stop the machine and take the time to look things over.

Never operate the machine when under the influence of alcohol, drugs, or medication.

Use the machine only in daylight.

Keep all nuts and bolts tight and keep the equipment in good operating condition.
 Always cut the ends of the log you are splitting as squarely as possible.

Never split more than one log at a time unless you fully extended the ram and you need a second log to complete the split of
the first log.

Never put anything between the log trays and the side of a log; logs spread as they are forced against the wedge.
 Never operate the wedge in a stalled position for more than five (5) seconds. The hydraulic fluid may overheat and damage
the machine. If the wood being split is excessively hard, stop the machine, rotate the log 180 and try again. If you still
cannot split the log, reject the log as it exceeds the capacity of the machine.

Never leave the Log Splitter unattended while plugged in. If you leave the area, unplug from the power source.
 Clean up as you work; accumulated split wood and wood chips can create a hazardous work environment.

Keep your hands and feet away from the splitting area while the wedge is in motion.

Use only your hands to operate the Log Splitter controls.
 Do not place your hands at pinch points where they can catch between a log and the wedge, log trays or the ram.

Do not put any part of yourself, your clothing, or your personal protective equipment into a crack in a log that you are
splitting; it might close suddenly with great force.

Never split anything other than logs free of nails, wires, and branches. Maximum log length is 20" with a maximum diameter
of 24" for the DR DUAL-ACTION ELECTRIC LOG SPLITTER.

Never operate the Log Splitter in an area of natural gas or flammable liquids.

Always operate the Log Splitter from the operator zone (Chapter 3). Never stand on, straddle, or climb over the Log Splitter
at any time.
 Do not handle logs by their ends when you position them on the Log Splitter. Handle from the sides of the log.

Always unplug the Log Splitter from the power source before adjusting or servicing the machine. If you have to stop to
remove any debris from the machine, always retract the ram and unplug the machine.

Do not move or reposition the Log Splitter with its motor running.
 Check the Log Splitter before turning it on. Never use the machine without ensuring that all guards and shields are in place.
Replace damaged, missing or failed parts before using the Splitter.

Never, under any conditions, remove, bend, cut, fit, weld, or otherwise alter standard parts on the Log Splitter. This includes
all shields and guards. Modifications to your machine could cause personal injuries and property damage and will void your
warranty.

Know how to stop the Log Splitter quickly; see “Stopping the Log Splitter” in Chapter 3.

Never operate your unit on a slippery, wet, muddy, or icy surface. Exercise caution to avoid slipping or falling.