Polaris 2013 BRUTUS Owner's Manual - Manual (Page 81)

80
MAINTENANCE
Periodic Maintenance Chart
► Perform these procedures more often for vehicles subjected to severe use.
E Emission-Related Service
D Have an authorized POLARIS dealer perform these services.
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Calendar Miles
(Km)
D Alternator/Fan/Water pump drive belt 50 H - - Check and adjust the V-belt after the initial 50 hours of operation; per-
form every 200 hours thereafter
D Air conditioning drive belt (if applicable) 50 H - - Check and adjust the V-belt after the initial 50 hours of operation; per-
form every 200 hours thereafter
► E Engine oil & filter change 50 H - - Perform an oil and filter change after the initial 50 hours of operation;
perform every 100 hours or 6 months thereafter
Hydraulic / hydrostatic system 50 H - - Replace hydraulic filter only after the initial 50 hours of operation;
replace hydraulic fluid, filter and reservoir breather cap every 400
hours thereafter
Battery 50 H 1 M - Check terminals; clean; test
E Fuel filter / water separator 50 H 3 M - Drain every 50 hours (normal conditions with quality fuel) or daily
(severe conditions with poor fuel quality)
► General grease lubrication 50 H 3 M 500 (800) Lubricate all grease fittings, pivots, etc.
E Air intake ducts / adapters 50 H 6 M - Inspect ducts for proper sealing/air leaks
Attachment interface mounting hardware
(HD/HD
PTO )
100 H - - Re-torque the lower mounting bolts to 95 ft-lbs
PTO gearbox (if equipped) 100 H - - Inspect for leaks
► E Engine oil & filter change 100 H 6 M - Perform an oil and filter change after the initial 50 hours of operation;
perform every 100 hours or 6 months thereafter
► Front / rear suspension 100 H 6 M 1000 (1600) Inspect for wear
Shift cable / linkage 100 H 6 M 1000 (1600) Inspect, lubricate, adjust
D Steering 100 H 6 M 1000 (1600) Inspect steering freeplay
D,E Travel Control And Engine Speed Control
System
100 H 6 M 1000 (1600) Inspect for proper operation and adjust if necessary