Lukas LH2 - Manual (Page 25)

25
WARNING / CAUTION / ATTENTION!
To perform maintenance and repairs, personal safety equipment appropriate for
the work is an absolute requirement. (incl. shields).
Assembly and repair work on the pump may only be performed if the entire
hydraulic system is depressurised!
Couplings should not be repaired; they should be replaced with original LUKAS
parts!
NOTE:
Always send the warranty tab back to LUKAS hydraulics GmbH.
You should always contact LUKAS or an authorised dealer before using outside
couplings.
Do not perform any repairs without the corresponding LUKAS spare parts list,
because necessary tightening torques for screw connections and/or in some
cases also important additional information are listed there.
The equipment is subject to very high mechanical stresses. Therefore, a visual inspection
needs to be made after each use, at least once per month (if continually used, once per
week).
In this way, early signs of wear are recognisable so that damage to the device can be
avoided by prompt replacement of these worn parts. Also check regularly to make sure that
all attachment screws are tightened (heed any applicable tightening torque specifications).
At least once a year (if continually used once every half year) or if there is a doubt about
the safety or reliability, a functional check should be also performed (for this purpose, also
heed the corresponding applicable national and international specifications related to the
maintenance intervals of the devices).
ATTENTION!
Clean the device before checking for dirt!
Do not use any aggressive agents for cleaning; it could cause damage to the
equipment.
Because LUKAS devices are designed for the highest performance, only
components may be replaced that are listed in the spare parts lists of the
corresponding device.
Additional components of the equipment may only be replaced if:
- You have participated in a corresponding LUKAS service training course.
- You have the express permission of LUKAS customer service (by request,
check on the grant of permission. A check is necessary in each individual
case).