General statement, Optichill chillers – Airedale OptiChill FreeCool 500kW - 1365kW User Manual
Page 4
![background image](/manuals/370936/4/background.png)
OPTICHILL
Chillers
4
Chillers
Installation & Maintenance : 6564868 02/2013
General Statement
IMPORTANT
The information contained in this manual is critical to the correct operation and
maintenance of the unit and should be read by all persons responsible for the installation,
commissioning and maintenance of this Airedale unit.
SAFETY
The equipment has been designed and manufactured to meet international safety
standards but, like any mechanical/electrical equipment, care must be taken if you are to
obtain the best results.
CAUTION
1
Installation, service and maintenance of Airedale equipment should only be
carried out by technically trained competent personnel.
CAUTION
2
When working with any air conditioning units ensure that the electrical isolator
is switched off prior to servicing or repair work and that there is no power to
any part of the equipment.
3
Also ensure that there are no other power feeds to the unit such as fire alarm
circuits, BMS circuits etc.
4
Electrical installation commissioning and maintenance work on this equipment
should be undertaken by competent and trained personnel in accordance with local
relevant standards and codes of practice.
5
The refrigerant used in this range of products is classified under the COSHH
regulations as an irritant, with set Occupational Exposure Levels (OEL) for
consideration if this plant is installed in confined or poorly ventilated areas.
6
A full hazard data sheet in accordance with COSHH regulations is available should
this be required.
SPARES
For ease of identification when ordering spares or contacting Airedale about your unit,
please quote the unit type, unit serial number and the date of manufacture, which can be
found on the unit serial plate.
A spares list for 1, 3 and 5 years will be supplied with every unit and is also available from
our Spares department on request.
SERIAL PLATE
The serial plate can be located to the inside of the control panel door, refer to
UK Office
+ 44 113 2391000
+ 44 113 2507219
Unit/Gerät/Unite
OPC500HED-8
Serial/Serie/Serie
81543668-001 (63091072)
Manufactured/Hergestellt/Fabriqué
24/01/2007
Supply/Spannung/Alimentation
400 V 3 PH 50 Hz
Fuse/Hauptsicherung/Fusibles
25.0 A
Test Pressure
27.0 BAR
Prüfdruck
Pression d’essai
Refrigerant & Charge
Kältemittel und Füllung
Refrigerant & Charge
Max. operating pressure
Betriebsdruck (Maximal)
Pression de marche (Maximum)
N.B. No: 0086
www.airedale.com