Freerider FR510DXs2b(Kensington-S) - Manual (Page 24)

24
Warning:
BATTERY INSTALLATION
Caution:
Your Scooter is equipped with two maintenance
free 12 volt batteries. The batteries are linked together by
wiring cables to supply the electronic system with 24 volts of
power
When first installing the batteries follow these assembly
instructions.
1. Connect the red wire of the battery cable to the
positive (+) terminal of the battery, with the provided.
2. Connect the black wire of the battery cable to the
negative (-) terminal of the battery, with the provided.
3. Repeat this procedure on the second battery making
certain the plastic red/black terminal covers are
secured over each terminal.
4. Position each battery onto the Scooter frame (see fig 32).
With the battery terminals to the outside and away from the
metal chassis.
Batteries are heavy you may require assistance.
5. Your batteries are located under the rear cover positioned
below your seat. The two batteries are secured to the
Scooter frame by velcro hold down straps. Each strap
frame passes from the chassis anchor point, around the
battery and through a metal loop positioned on the seat
mounting post. The strap is fastened tightly over the
battery and simply locks together via a velcro adhesive
technique (see fig 22 page21).
6. Connect the two grey plugs of the batteries into the two
grey sockets of the wiring circuit ( fig 33 ).
7. Switch on your Scooter, the battery meter will now
illuminate to show the state of charge in the batteries and
your Scooter is ready to drive.
8. Switch off your Scooter, fit the battery cover and seat.
Freerider
It is imperative that the two batteries are
connected correctly to prevent a short circuit between the
two batteries.
BATTERY INSTALLATION
Warning:
Caution:
Freerider
It is imperative that the two batteries are
connected correctly to prevent a short circuit between the
two batteries.
BATTERIES & BATTERY CHARGING
BATTERY CONNECTIONS
Warning:
BATTERY CHARGING
BATTERIES
Warning:
BATTERY CHARGER
Batteries are heavy, always handle with two hands.
You may require assistance. Do not allow metal tools to touch
both battery terminals together, this will cause an electrical
short and may damage the battery and injure you. Always
cover the battery terminals with the red/black plastic covers.
Your Scooter has a lot of power for a small Scooter.
Keeping it working to its maximum potential means that
its two batteries must be maintained with full power.
Nightly recharging, after use, will help you to give them a
longer life and will ensure your Scooter is always ready to
go when you are.
Your Scooter is fitted with two sealed maintenance-
free Batteries, especially designed for motive traction use.
This means that you do not have to worry about topping up
the cells.
Do not attempt to remove the safety valves
situated in the top of the battery. Failure to observe this
warning will invalidate your battery guarantee.
Your Scooter batteries are virtually Maintenance-free
because the electrolyte is immobilized in a special form and
therefore will not leak out, even if the battery is accidentally
overturned.
Because your
batteries are sealed they are more
likely to be accepted for carriage on aircraft. Please consult
your carrier prior to departure, as they will need advance
warning that you wish them to carry batteries.
Each carrier reserves the right not to carry
what may be termed 'HAZARDOUS CARGO'.
cannot be held responsible for their final decision.
Scooter and it may not be suitable for any other powered
mobility product. Only use the charger supplied with your
Scooter; other makes of charger may permanently damage
your batteries and would invalidate the Guarantee.
Freerider
Freerider
Please note:
The battery charger supplied, is special to your
CHARGING THE BATTERIES
Pleasese refer to the battery charger instruction attached
along with the battery charger.
BATTERY CONNECTIONS
Warning:
BATTERY CHARGING
BATTERIES
Warning:
CHARGING THE BATTERIES
Freerider
Freerider
Please note:
BATTERY CHARGER
FIG 33
Grey plugs
velcro strap
FIG 32
Grey plug
Batter
y
Front