DR Power 13 HP Towable - Manual (Page 47)

CALL TOLL FREE 1-800-DR-OWNER 43
CHAPTER 6
TROUBLESHOOTING
Most problems are easy to fix. Consult the Troubleshooting Table below for common problems and their
solutions. If you continue to experience problems, call Country Home Products, Inc. for support.
Troubleshooting Table
BEFORE PERFORMING ANY MAINTENANCE PROCEDURE OR INSPECTION, STOP THE ENGINE, WAIT FIVE (5)
MINUTES TO ALLOW ALL MOVING PARTS TO COME TO A COMPLETE STOP AND COOL. DISCONNECT THE
SPARK PLUG WIRE, KEEPING IT AWAY FROM THE SPARK PLUG.
S YMPTOM P OSSIBLE C AUSE
Recoil will not pull
out or is difficult to
pull (Manual Start
model). ⇒ Check for material build up clogged in the Chipper Hopper.
⇒ Check the engine oil level, the engine may be seized.
⇒ There may be an oil compression lock in the cylinder. Take out the spark plug; hold
a rag over the spark plug hole and pull the recoil cord several times to blow out any
oil in the cylinder. Wipe off the spark plug and reinstall it.
⇒ The recoil may be broken or jammed. Try to turn the engine pulley by hand, with the
spark plug wire off. If it turns, the recoil is broken or jammed. Call 1(800) DR-
OWNER (376-9637) for assistance.
The engine won’t
start manually.
(Please refer to the
Engine Owner’s
Manual for engine-
specific
procedures.)
⇒ Is the ON-OFF rocker switch in the ON position?
⇒ Is the spark plug wire properly attached?
⇒ Check the oil and gas level. See page 16.
⇒ Are you using fresh, clean gas? If the gas is old, change it. Use a fuel stabilizer if
you keep gas longer than one month.
⇒ Check that the fuel Shut-Off Valve is in the ON position.
⇒ Check the Fuel Filter (if equipped) to see if it is clear. Place a can under the Fuel
Filter and remove the fuel line from the engine side of the Filter. If gas flows freely,
it’s OK.
⇒ Check the Throttle adjustment and travel.
⇒ Is the spark plug clean? If the spark plug is dirty or cracked, change it. If it’s oily,
leave it out, hold a rag over the spark plug hole and pull the recoil cord several times
to blow out any oil in the cylinder, then wipe off the spark plug and reinsert it.
⇒ If your engine still won’t start, call 1(800) DR-OWNER (376-9637) for assistance.