Parts list, Fuel and oil, Test drive – Banks Power Jeep Trucks: (Gas ’91 - 06 Wrangler 4.0L) Sidewinder Jeep Turbo Jeep 4.0L I-6 models '05-06 User Manual
Page 22
22
96312 v.2.0
Fuel and Oil
1.
If you were not using 91 octane
gasoline, drain all fuel from the vehicle
and refill using 91 octane gasoline.
!
CAUTION: Using fuel with an
octane rating lower than 91 will
cause severe damage to engine
and/or turbo system.
2.
Fill vehicle with 10W-30 synthetic
motor oil. See vehicle owner’s manu-
al for quantity. We also recommend
replacing your oil filter.
!
NOTE: It is important to use
synthetic oil due to increased
oil temperature caused by the
turbocharger.
3.
Check engine bay for tools and
other items. Start vehicle and let idle
for several minutes. Shut down the
vehicle.
4.
Check for leaks. Check oil level
and add oil if needed.
Test Drive
!
NOTE: Banks Sidewinder
®
Tune must be successfully load-
ed before running vehicle.
1.
After ensuring that there are no
leaks, start the vehicle. Allow vehicle to
idle for several minutes to warm-up.
2.
Test drive vehicle in a loca-
tion with minimal traffic. Drive for
several minutes staying under 3000
rpm where possible. Safely monitor
engine temperature and boost pres-
sure. Shut down vehicle if engine
temperature increases above 245
degrees Fahrenheit or if boost pres-
sure increases above 7 psi.
3.
Park in a safe location and allow
vehicle to idle. Exit vehicle and check
for any leaks, including oil, fuel, and
exhaust.
4.
If no leaks are found, continue
to drive vehicle. Take caution while
driving until you are comfortable with
the additional performance of the
Sidewinder
®
Turbo System.
Parts List
24244
Sidewinder Turbo System, Non-Intercooled, w/AutoMind HH Prgrmr - 2005-06 Jeep Wrangler, 4.0L I-6
Qty
24240-1
Owner's Manual & Installation Kit, Turbo Systems - 99-06 Jeep 4.0L
1
24240-2
Turbocharger, 6-PSI W/G & Mounting Bracket Assembly, Turbo Syst - 99-06 Jeep 4.0L
1
24240-3
Lubrication Parts Kit, Turbo Syst - 99-06 Jeep 4.0L
1
24240-4
Exhaust Components Kit, Turbo Syst - 99-06 Jeep 4.0L
1
24240-6
Ram-Air Components Kit, Turbo Syst - 99-06 Jeep 4.0L
1
24240-7
Fuel Injection Parts Kit, Turbo Syst - 99-06 Jeep 4.0L
1
24244-5
Boost Tube Kit, Turbo Syst - 05-06 Jeep 4.0L
1
26110
Heatshield, Turbocharger/Turbine Outlet Pipe, Turbo System - 99-06 Jeep 4.0L
1
66124
AutoMind Programmer, Hand Held, Sidewinder Turbo only - 99-06 Jeep 4.0L
1
24240-1
Owner's Manual & Installation Kit, Turbo Systems - 99-06 Jeep 4.0L
Qty
26015
Tie, Heatshield Fastener
3
26062
Heatshield, Starter - Ford 460 Efi Truck/Motorhome
1
63001
Mounting Panel, One Gauge - Black, W/Fasteners
1
64050
Boost Gauge Kit, 0-15 PSI
1
90001
Threadlocker, Blue .5Ml
1
90040
Thread Sealant w/PTFE - 1oz Tube
1
90045
Anti Seize, 5 Grams -
1
92841
Hose Clamp, #40 W/Liner
1
93013
Gasket, Turbine Outlet - 99-06 Jeep 4.0L
1
96002
Decal, Stop Do Not Discard - Ram Air Filter
1
96009
Urocal, Banks Power, Small - Red, Black & Silver
2
96312
Owners Manual, Sidewinder Turbo Syst - 1999-06 Jeep 4.0L
1
96399
Product Registration Card - All Products
1
97173
Logo Plate, Banks - Super-Scoop, Jeep Turbo System
1