Martin Christ Beta 2-8 LSCplus - Manual (Page 27)

Beta 1-8 LSC&
Beta 2-8 LSC&
3 Safety
Version 04/2013, Rev. 1.1 of 16/12/2013 • sb
27
Translation of the original operating manual
Pos: 68 / 200 Christ /36 0 GT -BA La bor -Pilot (S TANDARDMODULE) /03 0 Sicher heit/ 030 -00 70 Sic her heitsei nricht ung en- -- --- -- --- --- -- --- -- --- -- --- --- -- --- -- --- --- -- --- -- -- @ 6\m od_ 129 913 646 611 9_68 .docx @ 3 476 4 @ 2 @ 1
3.7 Safety devices
Pos: 69 / 200 Christ /36 0 GT -BA La bor -Pilot (S TANDARDMODULE) /03 0 Sicher heit/ 030 -00 70- 001 0 Syst emko ntr olle @ 6\m od_1 299 136 466 494 _68. docx @ 34 772 @ 3 @ 1
3.7.1 System check
An internal system check system monitors the data transfer and sensor
signals with regard to plausibility. Errors are detected by continuous self-
monitoring of the system. Error messages are displayed in the main
window under "Process & equipment messages" (chapter 6.5.1.1 - "Main
window "Manual"", chapter 7.2 - "Process and error messages").
Pos: 70 / 010 Unive rsalm odul e/ L ee rzeile @ 0\ mod _120 211 624 450 0_0. docx @ 11 4 @ @ 1
Pos: 71 / 200 Christ /36 0 GT -BA La bor -Pilot (S TANDARDMODULE) /03 0 Sicher heit/ 030 -00 80 V erh alten bei G efah re n un d Unf ällen Alp ha-G am ma @ 6\ mod _129 913 646 735 3_6 8.doc x @ 3 478 8 @ 2 @ 1
3.8 Procedures in the event of hazards and accidents
DANGER
Fire:
• A fire in the electrical control system must be extinguished with a CO
2
fire extinguisher!
• Burning oil must be extinguished with a CO
2
fire extinguisher or powder
fire extinguisher!
Hazardous electrical incident:
• Set the mains power switch of the control system to the "0" position in
order to interrupt the power supply completely.
Burns:
• Small-area burns (e.g. finger) should be cooled immediately with
lukewarm water for approximately 2 minutes.
• Large-area burns should not be cooled because of the resulting risk of
hypothermia.
• Cover the burns loosely and in a sterile manner (e.g. with a sterile
dressing).
• Cover the injured person with a blanket.
IF IN DOUBT, CALL THE EMERGENCY PHYSICIAN (AMBULANCE)!
Pos: 72 / 010 Unive rsalm odul e/ L ee rzeile @ 0\ mod _120 211 624 450 0_0. docx @ 11 4 @ @ 1
Pos: 73 / 010 Unive rsalm odul e/ L ee rzeile @ 0\ mod _120 211 624 450 0_0. docx @ 11 4 @ @ 1
Pos: 74 / 200 Christ /36 0 GT -BA La bor -Pilot (S TANDARDMODULE) /03 0 Sicher heit/ 030 -00 90 R estrisik en @ 6\ mod_ 129 913 646 774 4_6 8.docx @ 3 479 6 @ 2 @ 1
3.9 Remaining hazards
All CHRIST freeze-dryers were built state-of-the-art and according to the
accepted safety rules. Danger to life and limb of the operator, or of third
parties, or impairments of the units or other material assets, however,
cannot be completely excluded when the units are being used.
Use the freeze-dryer
• only for the purpose that it was originally intended for (see chapter 1.2 -
"Intended use") and
• only if it is in a perfect running state.
• Immediately eliminate any problems that can affect safety.
Pos: 75 / 010 Unive rsalm odul e/ Absc hnittsw echsel @ 0\ mod _12 021 245 140 62_0 .docx @ 4 18 @ @ 1
Pos: 76 / 010 Unive rsalm odul e/ Seit enwec hsel @ 0\m od_ 120 211 6244 312 _0. docx @ 10 5 @ @ 1