Maintenance, Troubleshooting table, Replacement parts – Avalon Firestyles AGP Pellet User Manual
Page 46
46
Maintenance
© Travis Industries
4141230
100-01341
Troubleshooting Table
Lights on the control panel will flash when a fault has occurred. Follow the steps below to diagnose the
problem before calling customer service.
Diagnostic Code:
Possible Cause:
Don't Call for Service
Until You:
RED “STOP” LIGHT
FLASHING
A failed combustion blower, pressure switch
or push auger.
Press the START button again to
try to re-ignite the appliance.
RED “STOP” & GREEN
“START” LIGHTS LIT SOLID
Two consecutive startup attempts have failed. Verify the appliance has pellet
fuel and clean the burn platform.*
BLUE “AUTO FAN” LIGHT
FLASHING
Safety disc(s) tripped and appliance has
entered safety shutdown mode. The
appliance will no longer feed pellets and both
blowers will remain on until the appliance has
cooled sufficiently.
Verify the appliance is clean, free
of ash and debris and that the
blowers operate and are clean.
Press and hold the “STOP”
button for 3 seconds to clear the
diagnostic code.*
RED “STOP” & GREEN
“START” LIGHTS FLASH
ALTERNATELY
Appliance ran out of fuel or hopper lid not fully
close. In rare cases, the metering motor or
system disc may have malfunctioned.
Verify the appliance has pellet
fuel and hopper lid closes fully to
press the hopper lid switch.*
* Attempt to re-ignite the appliance after troubleshooting steps.
NOTE: Always check to make sure pellets are in the hopper and the fire platform is clean.
Replacement Parts
Contract your Travis Industries Dealer for replacement parts. Use only replacement parts from Travis
Industries designed specifically for this heater.
Door Parts
ID #
Description
Qty
Part #
ID #
Description
Qty
Part #
1
Glass Gasket (3/8” Diameter)
1
250-02801
2
Glass – Rectangular
Glass - Arched
1
1
250-02073
250-02678
3
Glass Clips w Gasket
1
250-00174
4
Door Gasket (7/8” Diameter)
1
250-00178
5
RTV High Temp. 600° Silicone
6
Door Handle Assembly
1
250-02074
7 Door
Knob
1 250-02964
8 Door
Washer
1 250-00364
9 Door
Cam
1 250-00598
10
Screws (8) 8-32 x 1/2” Torx
1
250-01478
7
8
9
1
2
3
4
10
5
6