JLG 800A_AJ ANSI Service Manual - Manual (Page 21)

SECTION 1 - SPECIFICATIONS
3120740 – JLG Lift – 1-1
SECTION 1. SPECIFICATIONS
1.1 OPERATING SPECIFICATIONS Capacities
1.2 COMPONENT DATA
Engine Data
Table 1-1. Operating Specifications
Travel Speed
2WD
4WD
3.0 MPH (4.83 Km/hr.)
3.0 MPH (4.83 Km/hr.)
Gradeability
2WD
4WD
30%
45%
Turning Radius (Outside)
2WS
4WS
22 ft.- 6 in. (6.86 m)
14 ft.- 6 in. (4.42 m)
Turning Radius (Inside)
2WS
4WS
12 ft.- 0 in. (3.66 m)
11 ft.- 0 in. (2.13 m)
Overall Width 8 ft.-0 in. (2.44 m)
Machine Height Stowed 9 ft. 9.5 in.(2.98 m)
Machine Length (Stowed)
800A
800AJ
36 ft.-9 in. (11.25 m)
36 ft.-6 in. (11.13 m)
Wheel base 10 ft.- 0 in. (3.05 m)
Boom Elevation - 800A
Above Grade
Below Grade
+80 ft.-3 in. (24.46 m)
-15 ft.-7 in. (4.75 m)
Boom Elevation - 800AJ
Above Grade
Below Grade
+80 ft.-3 in. (24.46 m)
-13 ft.- 1 in. (3.99 m)
Max. Ground Bearing Pressure
84 psi. (5.9 kg/cm 2 )
Max. Tire Load 17,755 lbs. (8060 kg)
Drive Speed (2WD)
Forward
Reverse
42 - 48 Seconds for 200 Ft
42 - 48 Seconds for 200 Ft
Drive Speed (4WD)
Forward
Reverse
42 - 48 Seconds for 200 Ft
42 - 48 Seconds for 200 Ft
Machine Weight approximately
IN 385/65D 19.5 Pneumatic
15 X 19.5 Pneumatic
IN 445/55D 19.5
18 X 19.5 Pneumatic Tires
IN 385/65D 19.5
15 X 19.5 Foam Filled Tires
IN 445/55D 19.5
18 X 19.5 Foam Filled Tires
34,200 lbs.(15,520 kg)
34,200 lbs.(15,520 kg)
34,270 lbs. (15,550 kg)
34,270 lbs. (15,550 kg)
33,100 lbs. (15,020 kg)
33,100 lbs. (15,020 kg)
33,550 lbs. (15,220 kg)
33,550 lbs. (15,220 kg)
Table 1-2. Capacities
Fuel Tank Approx. 40 gallons (151.4 liters)
Hydraulic Tank Approx. 40 gallons (151.4 liters)
Hydraulic System (Including Tank) 77 Gal. (291.4 L)
Drive Hub* (Prior to S/N 83332) 17 ounces (0.5 L)
Drive Hub* (S/N 83332 to Present) 44 ounces (1.3 L)
Drive Brake (S/N 8332 to Present) 2.7 ounces (80 ml)
Engine Oil Capacity
Ford
Deutz
Cooling System
Crankcase
Total Capacity
Caterpillar
Isuzu
GM
4.5 Quarts (4.25 L) w/Filter
5 Quarts (4.5 L)
11 Quarts (10.5 L) w/Filter
16 Quarts (15 L)
10.6 quarts (10 L)
8.5 Quarts (8.0 L)
4.5 Quarts (4.25 L) w/Filter
NOTE: Torque hubs should be one half full of lubricant.
Table 1-3. Ford LRG-425 Specifications
Type Water-cooled
Fuel Gasoline
Oil Capacity 4.5 Quarts (4.25 L) w/Filter
Idle RPM 1000
Low RPM 1800
High RPM 2800
Alternator 95 Amp, Belt Drive
Fuel Consumption
Low RPM
High RPM
3.45 GPH (13.06 lph)
4.60 GPH (17.41 lph)
Battery 1000 Cold Cranking Amps, 210
minute reserve Capacity, 12 VDC
Horsepower 74 @ 3000 RPM, full load
Cooling System 16 Quarts (15.14 L)
Spark Plug AWSF-52-C
Spark Plug Gap 0.044 in. (1.117 mm)