JLG X19J Operator Manual User Manual
Page 135
131
7.23 BATTERY PACK OPERATING SPECIFICATIONS
The battery pack must be used and handled with care to ensure safe operation and maxi‑
mum machine performance.
The battery pack has a rated voltage of 48 Vdc; any modifications made by unauthorised per‑
sonnel invalidate the warranty and may cause damage to the machine and harm to people
and things.
Only qualified personnel are authorised to handle and access the battery pack.
The battery pack is made up of just one module positioned at the rear of the machine. The
weight of the battery pack is approximately 80 kg.
In case of problems, only authorized personnel are authorised to access the battery pack and
replace it.
Additional electronic devices may have a negative influence on the correct operation of the
electronic components provided on the machine. For this reason it is absolutely forbidden to
use any devices on the vehicle that do not comply with directive 72/245/EEC and its subse‑
quent amendments (2005/49/EC, 2005/83/EC, 2006/28/EC).
The constructor accepts no liability for any damage due to failure to comply with this war‑
ning.
Opening and handling the battery pack is dangerous. Failure to observe this warning auto‑
matically voids the warranty.
NEVER OPEN THE BATTERY PACK
The battery pack works at peak performance and in safe conditions with an ambient tempe‑
rature between ‑20°C and 40°C. Using the battery pack out of this temperature range may be
dangerous.
Avoid leaving the machine in sunny and badly ventilated places for long periods.
The battery pack is connected to the motor control via a 100 A fuse.
The fuse may be replaced only by qualified personnel.
Always keep the battery charged. Recharge the battery pack whenever considered necessary,
even if the battery has not completely run down.
To check the battery level use the special indicator provided. The battery level depends on
many factors, for this reason, to avoid incorrect reading of the indicator, always keep the bat‑
teries charged. If the machine is not used for extended periods, recharge at least every 3
months.
BOOM LIFT MODELS X19J
JLG
X19JR0620113
ATTENZIONE
WARNING