Introduction, Dispensing mechanisms, Media condition – Triton 97XX Series Operation Manual User Manual
Page 37: Warning, 97xx-series, Peration, Anual, Odel
O
PERATION
M
ANUAL
- M
ODEL
97XX-Series
4-2
SECTION 4 - CURRENCY HANDLING
TRITON SYSTEMS, INC.
Introduction
The purpose of this section of the manual is to de-
scribe the procedures for: (1) Removing and replac-
ing note cassettes, (2) Loading cassettes, and (3)
Removing and replacing the Reject Notes (as appli-
cable). Information concerning note handling and
quality issues are explained where appropriate.
Dispensing Mechanisms
The 97XX series Cash Dispensers use a variety of
dispensing mechanisms. Depending upon Cash Dis-
penser model, the dispensing mechanism may hold
one or more Note Cassettes. The Reject collection
method may use a reject compartment that is inte-
grated into the Note Cassette, or a separate reject
container. Currency capacity depends upon the dis-
penser mechanism installed in the Cash Dispenser,
but is also affected by note quality and thickness. Typi-
cal capacities are provided in the following table:
The dispensing mechanism delivers the appropriate
number of notes from the Note Cassette(s) to fulfill
the customer’s withdrawal request. The purpose of
the Reject area or vault is to accept and hold notes
that have been transferred from the Note Cassette(s)
but not dispensed. Some situations that could cause
the mechanism to reject notes are: (1) Multiple notes
stuck together and (2) Note width too short or long.
Other conditions that could cause a reject are de-
scribed in the next section, Media Condition.
S
E
I
L
I
M
A
F
L
E
D
O
M
X
X
7
9
Y
L
I
M
A
F
L
E
D
O
M
E
T
T
E
S
S
A
C
Y
T
I
C
A
P
A
C
Y
C
N
E
R
R
U
C
E
T
A
M
I
X
O
R
P
P
A
s
e
i
r
e
S
-
0
0
7
9
e
t
t
e
s
s
a
C
e
l
g
n
i
S
s
e
t
o
N
0
0
1
2
s
e
i
r
e
S
-
5
0
7
9
e
t
t
e
s
s
a
C
e
l
g
n
i
S
s
e
t
o
N
0
0
0
1
-
0
5
5
s
e
i
r
e
S
-
0
1
7
9
e
t
t
e
s
s
a
C
e
l
g
n
i
S
s
e
t
o
N
0
0
0
1
-
0
5
7
s
e
i
r
e
S
-
0
5
7
9
e
t
t
e
s
s
a
C
e
l
p
i
t
l
u
M
/
e
l
g
n
i
S
e
t
t
e
s
s
a
c
r
e
p
s
e
t
o
N
0
0
0
3
Media Condition
If possible, store currency at room temperature for at
least eight hours before dispensing from the cassettes.
The number of rejects can be directly influenced by
the technique used to load the cassettes and the qual-
ity of the currency. Notes loaded into the cassettes
must be in “fit” condition if a high level of performance
(low reject and failure rate) is expected from the unit.
“Fit” notes do not possess any of the defects listed
here:
Used Note Defects
•
Adhesive or “sticky” substances on the surface of
the paper.
•
Tears extending more than 1/2” from the edge of
the currency.
•
Tears, holes, or missing sections in the body of
the currency.
**WARNING**
DO NOT RECYCLE REJECTED NOTES
INTO A CASSETTE! Doing so could cause
more rejects and/or currency jams.
LEARNING NOTES
IMPORTANT! The first time a 9705 or 9750-se-
ries dispenser is used, the mechanism will enter
a learning mode, during which it will reject some
notes as it learns the average thickness of the
currency. In such cases, it is recommended that
you remove the rejected notes from the unit be-
fore placing the Cash Dispenser into service.