Great Plains YP1625A Operator Manual - Manual (Page 51)

Great Plains Manufacturing, Inc. Table of Contents Index Operating Instructions 47
2013-08-13 Table of Contents Index 401-625M
Storage
Store the planter where children do not play. If possible,
store the planter inside for longer life.
1. Empty hopper (page 90).
2. Close the seed box or hopper door (page 91).
Clean out the air system (page 91).
3. Remove hopper or seed box (page 34).
4. Cover and seal off the opening at the top of the air
box. Leave clean-out door slightly ajar to allow any
condensed moisture to drain off.
5. Remove seed disks from meters (this is primarily to
relieve pressure on brushes). Clean disks of residue
build-up (see Caution at right). Use mild soap,
non-abrasive scrubbers, and hot or warm water. If
using sealed storage, dry disks prior to storage.
6. Close seed inlet shutters at meters (to prevent pest
entry to seed hoses). Thoroughly clean seed and
seed treatment residue from seed meters. See
“Meter Clean-Out” on page 92, for more information.
7. If your planter is equipped with an optional fertilizer
tank, clean tank and application hoses. Be sure to
follow chemical manufacturer’s instructions when
handling chemicals.
8. Thoroughly clean pump following instructions in the
pump manual.
9. Unscrew caps on end of fertilizer booms and flush
them out. Drain completely and replace caps.
10. Remove any dirt and debris that can hold moisture
and cause corrosion.
11. Lubricate and adjust all roller chains.
12. Smear grease on exposed cylinder rods to prevent
rust. Add a brightly-colored tag at the hitch as a
reminder to de-grease the rods prior to next use (to
avoid any risk that congealed grease might damage
seals).
13. See “Lubrication” on page 104, for lubrication
information.
14. Inspect planter for worn or damaged parts. Make
repairs and service during off season.
15. Use spray paint to cover scratches, chips, and worn
areas on the planter to protect the metal.
16. Cover planter with a tarp if stored outside.
Note: Removing the seed box/hopper increases the life
of the air box seals, which are otherwise apt to be
permanently compressed if stored under load
off-season.
Note: Do not store optional bulk hopper outside on the
ground. Raise it on blocks, securing it in place to
prevent from falling over or blowing around by
wind. Store inside if possible.
Possible Chemical Hazard:
Seed disks will have talc and graphite residue, and may have
residues of hazardous seed treatments. Do not wash disks
where food is prepared, or where cookware or dinnerware is
washed. Wear gloves when washing disks. Avoid spray.
Although the disks are dishwasher-safe, do not wash them in
an appliance also used for food cookware or dinnerware.
Storage: Fertilizer Option
The pump, strainer and manifold system require special
attention prior to storage. See “Fertilizer System
Maintenance” on page 102.