Henny Penny OEA/OGA-323 - Manual (Page 73)

Model OFE/OFG-321,322,323,324
G L O S S A R Y
HENNY PENNY OPEN FRYERS
air valve
a valve on the eight head fryer that allows air into the filter lines when the pump
is on in the mixing mode on eight head fryers
airflow switch
a switch that senses the amount of airflow coming from the blower; if the
airflow
(gas fryers only)
falls below a certain level, the switch cuts power to the gas control valve that
shuts down the burners
blower
located on the rear of a gas fryer, the blower pulls flue gases out of the flue and
(gas fryers only)
provides the proper amount of air to the burner tubes for efficient combustion
breading
a flour and seasoning mixture used to coat the product prior to frying
burner assembly
an assembly on gas fryers that houses the pilot light which ignites the gas that
(gas fryers only) heats the fryer
burner tubes
the tubes through which heated air is forced to heat the shortening
(gas fryers only)
carrier a wire frame inside the eight head frypot that holds five racks of product during
the cook cycle
casters
the wheels on bottom of the fryer that allow the unit to roll; casters should be
locked when unit is in use and not being moved; casters may be adjusted to help
level the fryer
cleaning solution
an agent used to clean the frypot; see recommended cleaning procedures
cold zone
an area in the bottom of the frypot where shortening is cooler than the area
above; the zone allows the crumbs to settle without burning
cook cycle
a programmed cycle that cooks a particular product at a preselected temperature
and for a preselected time
cooking load
the amount of product cooked during a cook cycle
counterweight
the weights shipped with the fryer that, when installed in the counterweight
assembly, enable the eight head fryer lid to lift easily
counterweight assembly
an assembly of weights and cables that enable the eight head fryer lid to lift
easily
cover
a protective lid for the frypot when fryer is not in use
cracklings
the crumbs of breading that come off the product during a cook cycle
crumb catcher
the part of the filter assembly on four head fryers that filters crumbs out of the
shortening before the shortening is pumped back into the frypot
203 G-1