Maintenance work on chassis and engine – KTM 450 EXC-R EU User Manual
Page 76
MAINTENANCE WORK ON CHASSIS AND ENGINE
74
Fitting the main silencer
400337-11
ದ
Check parts for damage and wear. Replace damaged or worn parts.
ದ
Mount the main silencer. Mount and tighten screws
b
.
Specification
Remaining screws, chassis
M6
10
bNm (7.4blbfbft)
ದ
Reconnect spring
b
.
Dismounting the air filter box lid
400338-10
ದ
Pull off the air filter box lid in area
b
to the side and remove to the front.
Installing the air filter box lid
400338-11
ದ
Check parts for damage and wear. Replace damaged or worn parts.
ದ
Insert the air filter box lid into the rear area
b
and clip it into the front area
b
.
Removing the air filter
b
x
Note
Engine failure
ಘUnfiltered intake air has a negative effect on the service life of the engine.
ದ
Never ride the vehicle without an air filter since dust and dirt can get into the engine and result in increased wear.
Warning
Environmental hazard
ಘProblem materials cause environmental damage.
ದ
Dispose of oil, grease, filters, fuel, cleaning substances, brake fluid, batteries, etc. according to regulations.
ದ
Dismount the air filter box lid. (
P. 74)
500107-10
ದ
Hang the air filter holder
b
out to the bottom and swing it to the side. Remove the
air filter with the air filter support.
ದ
Remove the air filter from the air filter support.