Lull 944E-42 Service Manual - Manual (Page 836)

12.2 Model 644E-42/944E-42 Rev. 6/04
Index
Park Brake Warning
Indicator ................................. 9.157
Stabil-TRAK
"Locked" Mode Indicator ....... 9.160
Stabil-TRAK "Slow Pivot"
Mode Indicator ....................... 9.161
Transmission Temperature
Warning Indicator................... 9.154
Drain and Flush Radiator ................ 7.12
Drive Shafts
Inspection and Service ............... 5.16
Installation................................... 5.17
Maintenance ............................... 5.16
Removal...................................... 5.16
Dual Joystick ................................. 9.227
E
ECM Fuses ............................ 9.23, 9.26
Electrical Component Terminology
General Overview (644E-42 Vehicle
Power Harness) .................. 9.6, 9.7
General Overview (944E-42 ECM
Vehicle Power & ECM Cab
Harnesses) ................................ 9.8
General Overview (Open Cab
Harness) .................................... 9.5
General Overview (Optional Closed
Cab Harness)........................... 9.12
General Overview
(Optional Closed Cab
Harness) .................................. 9.13
General Overview (Optional
Roadlights Harness) ................ 9.14
General Overview (Optional
Worklights Harness)................. 9.15
General Overview (Vehicle Control
Harness) .................................. 9.10
General Overview (Vehicle Ground
Strap Locations)....................... 9.16
General Overview (Vehicle Sensor
Harness) .................................... 9.9
General Overview (Vehicle
Transmission Harness) ............ 9.11
Electrical System
Charging Circuit ........................ 9.167
Components ............................. 9.176
Dash Panel Warning
Indicator Troubleshooting ...... 9.148
Effective Ground
Connections ............................. 9.19
Electrical Troubleshooting .......... 9.27
Engine Start Circuit................... 9.163
Fuses and Relays ....................... 9.21
Service Warnings........................ 9.18
Specifications.............................. 9.18
Switches and Solenoids............ 9.209
Terminology...................................9.5
Transmission Gear Selection
Troubleshooting......................9.140
Warning Devices .......................9.176
Warning Indicator Lights............9.178
Wiring Harnesses ........................9.19
Electrical System Components
944E-42 Throttle Position
Sensor ...........................4.16, 9.186
Back-Up Alarm ..........................9.179
Cab Heater/Air Conditioning
Controls ..................................9.206
Front Dash Panel ......................9.181
Front Windshield
Wiper Motor ............................9.190
Front Windshield
Wiper Switch ..........................9.188
Rear Wiper Motor ......................9.202
Skylight Wiper Motor .................9.198
Skylight Wiper/Washer & Rear
Window Washer Switch..........9.196
Windshield/Skylight/Rear Wiper
Washer Reservoir w/Pump.....9.200
Electrical System Troubleshooting
644E-42 Engine Start Circuit.......9.70
644E-42 Engine With Optional Cold
Start Circuit.............................9.104
644E-42 Vehicle Power Harness
Electrical Schematic ........9.52, 9.53
944E-42 ECM Vehicle Power & ECM
Cab Harnesses Electrical
Schematic.................................9.54
944E-42 Electronic Throttle
Circuit .......................................9.82
944E-42 Engine Start Circuit.......9.76
Air Conditioning Circuit..............9.112
Cab Heater & Air Conditioning Blower
Motor ......................................9.110
Charging Circuit...........................9.84
Dual Joystick Auxiliary Hydraulic
Circuit .......................................9.86
Electrical Symbols
Directory ...................................9.47
Flash High Beam Circuit (Option).......
9.134
Front Wiper/Washer Circuit .......9.114
Introduction..................................9.27
Light Power Relay (Option) .......9.120
Main Electrical
Schematic........................9.48, 9.50
Main Electrical
Schematic Legend....................9.35
Optional 644E-42 Cold Start Electrical
Schematic........................9.56, 9.57
Optional 644E-42 Cold Start Electrical
Schematic Legend....................9.55
Optional Closed Cab Electrical
Schematic ................................ 9.63
Optional Closed Cab Electrical
Schematic Legend ................... 9.62
Optional Roadlight Electrical
Schematic ................................ 9.66
Optional Roadlight Electrical
Schematic Legend ................... 9.64
Optional Single Joystick
(Early Production)
Electrical Schematic................. 9.59
Optional Single Joystick
(Early Production) Electrical
Schematic Legend ................... 9.58
Optional Single Joystick
(Late Production)
Electrical Schematic................. 9.61
Optional Single Joystick
(Late Production) Electrical
Schematic Legend ................... 9.60
Optional Worklight Electrical
Schematic ................................ 9.69
Optional Worklight Electrical
Schematic Legend ................... 9.68
Probing Electrical
Connectors............................... 9.30
Rear Wiper Circuit..................... 9.118
Roadlight Brake Lights
Circuit (Option) ....................... 9.132
Roadlight Hazard Lights
Circuit (Option) ....................... 9.128
Roadlight Low Beam Lights
Circuit (Option) ....................... 9.124
Roadlight Parking Lights
Circuit (Option) ....................... 9.126
Roadlight Turn Signals
Circuit (Option) ....................... 9.130
Roadlight Worklights
Circuit (Option) ....................... 9.136
Roadlights High Beam
Circuit (Option) ....................... 9.122
Single Joystick Auxiliary Hydraulic
Circuit (Option) ......................... 9.90
Single Joystick Transfer Carriage
Extend/Retract Circuit (Option) 9.94
Single Joystick - Boom Attachment
Tilt Circuit (Option) ................. 9.100
Single Joystick - Boom Extend/
Retract Circuit (Option) ............ 9.96
Single Joystick - Boom Lift/Lower
Circuit (Option) ......................... 9.98
Skylight Wiper/Washer, Rear Washer
Circuit ..................................... 9.116
Troubleshooting with a Digital
Multimeter (DMM) .................... 9.29
Worklight (Without Roadlights) Circuit
(Option) .................................. 9.138
Emergency Exit Rear Window .......... 1.6