JLG X23J Operator Manual User Manual
Page 158
Avoid leaving the machine in sunny and badly ventilated places for long periods.
The battery pack is connected to the motor control via a 100 A fuse.
The fuse may be replaced only by qualified personnel.
Always keep the battery charged. Recharge the battery pack whenever considered necessary,
even if the battery has not completely run down.
To check the battery level use the special indicator provided. The battery level depends on
many factors, for this reason, to avoid incorrect reading of the indicator, always keep the bat‑
teries charged. If the machine is not used for extended periods, recharge at least every 3
months.
7.26.1 C
OMPONENTS AND DIAGRAMS
BATTERIES
The battery pack must be used and handled with care to ensure safe operation and maxi‑
mum machine performance.
The battery pack has a rated voltage of 70 Vdc; any modifications made by unauthorised per‑
sonnel invalidate the warranty and may cause damage to the machine and harm to people
and things.
Only JLG technical personnel are authorised to handle and access the battery pack.
The battery pack is made up of just one module positioned at the rear of the machine. The
weight of the battery pack is approximately 120 kg.
BATTERY REPLACEMENT & MAINTENANCE
In case of problems, only qualified personnel are authorised to access the battery pack and
replace it.
RECHARGING
Recharge the Battery System only using the special battery charger provided with the machi‑
ne.
Using a different battery charger may cause damage to the machine and pose a risk to the
operator.
Do not remove the cover and do not tamper with the battery charger.
Failure to observe these rules voids the machine’s warranty, may affect the correct operation
of the battery system and may cause damage to things and people.
Recharge the machine in a ventilated and dry place, at an external temperature not excee‑
ding 40°C and not below 0°C.
Always supervise the machine when recharging.
BOOM LIFT MODELS X23J
JLG
154
X23JR0620113
ATTENZIONE
ATTENTION