MacDon M205 Operators Manual - Manual (Page 431)

TROUBLESHOOTING
Symptom Problem Solution Section
Improper type of fuel
Consult your fuel supplier, and use
proper type fuel for conditions.
Fuel
Specifications,
page 284
Engine overloaded Reduce ground speed.
4.3.6 Windrower
Operation, page
157
Clogged or dirty air cleaner Service air cleaner.
Air Intake System,
page 319
Defective muffler
Check muffler for possible damage
that might create back pressure. Exhaust System,
page 346
Dirty or faulty injectors
Engine out of time
Engine emits black
or grey exhaust
Air in fuel system
Contact Dealer. Contact Dealer.
Engine out of time Contact Dealer. Contact Dealer.
Improper type of fuel
Consult your fuel supplier, and use
proper type fuel for conditions.
Fuel
Specifications,
page 284
Cool engine
Warm engine up to normal operating
temperature. Engine Warm-Up,
page 154
Engine emits white
exhaust
Defective thermostat Remove and check thermostat. Contact Dealer.
Low battery output Check battery charge.
Loose or corroded battery
connections
Clean and tighten loose connections.
Maintaining the
Battery, page 350
Move GSL to NEUTRAL.
4.3.6 Windrower
Operation, page
157
Move steering wheel to CENTER
position.
Driving in Reverse
in Cab-Forward
Mode, page 161
Controls not in NEUTRAL
Disengage header.
Engaging and
Disengaging the
Header, page 190
Relay not functioning Check relay and wire connections.
Main fuse defective/blown Replace main fuse.
Key power fuse blown Replace.
5.7.8 Electrical
System, page 350
Key switch worn or terminals
loose
Contact Dealer.
Switch at Interlock not closed
or defective Adjust switch or replace. Contact your
Dealer.
Contact Dealer.
Starter cranks
slowly or will not
operate
Crankcase oil too high
viscosity
Use recommended oil.
Lubricants, Fluids,
and System
Capacities, page
285
169887 415 Revision A